Analisis Perpindahan Panas pada Sirkulasi Air Penyulingan Nilam dengan Tangki Bervolume 150 Liter
Heat Transfer Analysis on Circulating Patchouli Distilled Water with a 150 Liter Volume Tank
Abstract views: 264 | pdf downloads: 579
Abstract
Indonesia is the world’s main exporter of patchouli plants (Pogostemon Cablin Benth). Patchouli plants produce essential oil by distillation; this essential oil has a constituent component called patchouli alcohol and is widely used in the aromatic industry. Therefore, a patchouli refining process is needed so that Indonesia’s patchouli can improve its quality in the eyes of the world. The purpose of this research is to observe the process of cooling hot patchouli steam into patchouli oil to optimize the current process. This study's analytical method is a simulation approach with CFD software. 50 kg of dried patchouli leaves and stems will go through a combustion process and then be distilled in a 150 liter volume tank for 5 hours. During the distillation process, there is a heat transfer phenomenon called conduction and convection. The LMTD value was 327 K, the heat transfer rate was 103,39 W, the overall heat transfer was 223,45 W/m2K, the NTU value was 0,018, and the system's effectiveness was 0.89% using LMTD and the -NTU method.
References
Bergman, T. L. dkk. (2011) Fundamentals of Heat and Mass Transfer. 7th edn. USA: John Wiley & Sons [Cetak].
BSN, - Badan Standardisasi Nasional - (2007) SNI 06-2385-2006: Minyak Nilam, Detail SNI. Available at: http://sispk.bsn.go.id/SNI/DetailSNI/-CUSTOMER VALUE- (Diakses: 20 March 2021).
Elza, S.P. (2019) ‘Modifikasi Metoda Newton Raphson Nonlinear Geometri pada Sistem Struktur Rangka Sendi’, Rekayasa Sipil, 8(1), hal. 26–38.
Handayani, T. (2007) ‘Pemanfaatan Lahan Tidur Di Bawah Tegakan Hutan Rakyat Dengan Tanaman Nilam’, Jurnal Teknologi Lingkungan, 8(2), hal. 113–118.
Idris, A., Jura, M.R. dan Said, I. (2014) ‘Analisis Kualitas Minyak Nilam (Pogostemon Cablin Benth) Produksi Kabupaten Buol’, Jurnal Akademika Kimia, 3(2), hal. 79–85.
Mahlinda, M., Arifiansyah, V. dan Supardan, M.D. (2019) ‘Modifikasi Alat Penyuling Uap untuk Peningkatan Rendemen dan Mutu Minyak Nilam (Pogostemon cablin Benth)’, Jurnal Rekayasa Kimia & Lingkungan, 14(1), hal. 28–35.
Mahlinda dan Supardan, M.D. (2020) ‘Distillation of Patchouli Oil Using Firewood and Liquefied Petroleum Gas as Fuel: Effects of Yield, Quality and Cost Analyses’, in Journal of Physics: Conference Series. IOP Publishing, hal. 012059–012068.
Masruri (2015) Simulasi Uji Kebisingan (Noise) Pada Pompa Sentrifugal Skala Rumah Tangga Menggunakan Perangkat Lunak FEM. Thesis. Program Studi Teknik Mesin Fakultas Teknik Universitas Sumatera Utara [Cetak].
Salim, T. dkk. (2005) ‘Pengaruh Pemakaian Bahan Bakar Terhadap Kinerja Penyulingan Minyak Nilam Di Dua Daerah’, in Prosiding Seminar Nasional Teknologi Proses Kimia. Seminar Nasional Teknologi Proses Kimia, Jakarta: Jurusan Teknik Gas dan Petrokimia Fakultas Teknik Universitas Indonesia, hal. 55–60 [Cetak].
Souhoka, F.A., Al Aziz, A.Z. dan Nazudin, N. (2020) ‘Patchouli Oil Isolation and Identification of Chemical Components Using GC-MS’, Indonesian Journal of Chemical Research, 8(2), hal. 108–113.
Sukamta, S., Thoharudin, T. dan Nugroho, D.M. (2018) ‘Simulasi CFD Aliran Stratified Air-Udara pada Pipa Horisontal’, Semesta Teknika, 21(2), hal. 206–215.
Supriadi, Rizal, M. dan Wahyuno, D. (2011) Bunga Rampai Nilam (Pogostemon Cablin Benth). Bogor: Balai Penelitian Tanaman Obat dan Aromatik, Pusat Penelitian dan Pengembangan Perkebunan, Badan Penelitian dan Pengembangan Pertanian, Kementrian Pertanian [Cetak].
Yuliana, D.A., Aswan, A. dan Febriana, I. (2020) ‘Proses Pengambilan Minyak Atsiri Dari Tanaman Nilam (Pogestemon Cablin Benth) Menggunakan Metode Microwave Distillation’, KINETIKA, 11(3), hal. 34–39.
